Chapter 1 – Service Information, Work Orders, and Vehicle Identification (page 1)
Fire Extinguisher
Vehicle Hoisting
Work Order
Vehicle Service Information and TSBs
Vehicle Identification Number
Retrieve and Record DTCs, and OBD II Data
Chapter 4 – Clutch Diagnosis and Service (page 40)
Diagnose Clutch Concerns
Clutch Linkage Inspection
Inspect the Hydraulic Clutch
Inspect Clutch Components
Bleed Clutch Hydraulic System
Flywheel and Ring Gear Inspection
Flywheel Runout
Dual Mass Flywheel Inspection
Chapter 5 – Manual Transmissions Parts and Operation (page 59)
Manual Transmission/ Transaxle Identification
Chapter 6 – Manual Transaxles Parts and Operation (page 77)
Manual Transmission/ Transaxle Identification
Chapter 7 – Electronically Controlled Manual Transmission/Transaxle (page 84)
Electronically Controlled Manual Transmission
Chapter 8 – Manual Transmission/Transaxle Diagnosis and Service (page 92)
Diagnose Drive Train Concerns
Diagnose Fluid Condition & Loss
Drain and Fill Manual Transmission/Transaxle
Remove and Replace Transmission/Transaxle
Disassemble/Reassemble Transmission/Transaxle
Manual Transmission Noise/Shifting Diagnosis
Manual Transmission/Transaxle Linkage
Transaxle Final Drive Noise Diagnosis
Chapter 9 – Driveshafts and Half Shafts (page 121)
CV Joint Noise and Vibration Diagnosis
Chapter 13 – Drive Axle and Differential Diagnosis and Service (page 180)
Drive Axle Shaft Service
Drive Axle Flange Runout and Axle End Play
Drive Axle Shaft Wheel Studs
Drive Axle Seals, Bearings and Retainers
Differential Noise Diagnosis
Differential Fluid Leaks
Pinion Seal Replacement
Ring Gear Runout
Differential Assembly Inspection
Drive Pinion Depth
Drive Pinion Bearing Preload
Differential Side Bearing Preload
Ring and Pinion Tooth Pattern
Differential Pinion Gears and Case
Differential Case Assembly
Limited Slip Differential Diagnosis
Check, Drain and Refill Differential Case
Limited Slip Differential Rotating Torque
Chapter 14 – Drivetrain Electricity and Electronics (page 209)
Test Light Usage
Measure Voltage Using a Voltmeter
Measuring Current Using an Ammeter
Check Electrical Circuits Using an Ohmmeter
Circuit Testing Using a Fused Jumper Wire
Inspect Wiring and Connectors
Wire Harness and Connector Repair
Connectors and Terminals
Solder Wire Repair
Use Wiring Diagrams to Diagnose a Circuit
Module Communication
Chapter 15 – Four-Wheel and All-Wheel Drive (page 234)
Four-Wheel Drive Identification
Tire Circumference & Final Drive Ratio Variations
Chapter 16 – Four-Wheel Drive Diagnosis and Service (page 255)
Inspect and Adjust Shifting Controls
Transfer Case Replacement
Transfer Case Disassembly and Reassembly
Inspect Front Locking Hubs
Transfer Case Lube Level/Leak Check
Transfer Case Electrical Components
Chapter 17 – Vibration and Noise Diagnosis and Correction (page 271)
Noise and Vibration Diagnosis
Universal Joint Noise and Vibration Diagnosis
Driveshaft Phasing and Balance